| Mileage: | 150,000 miles |
| Year (Reg): | 1991 (J) |
| Transmission: | 5-Speed Manual |
| Colour: | Tornado Red |
| Engine: | 1.8 – Inline 4 |
| Fuel Type: | Petrol |
Comprehensive Nut & Bolt Restoration | 609 Hours Documented | Better Than New
There are restored Mk2 GTIs, and then there are restorations carried out with absolutely no compromise.
Offered here is an exceptional Volkswagen Golf GTI Mk2 which has undergone a meticulous, no-expense-spared restoration by renowned marque specialists DS Motorsport UK Ltd. Completed over an 18-month period between March 2023 and September 2024, the restoration totalled an incredible 609.25 documented workshop hours.
Importantly, this isn’t simply a cosmetic refurbishment. Every major mechanical, structural and cosmetic component has either been restored, rebuilt or replaced using genuine OEM or the highest quality available parts.
Although the odometer now reads approximately 150,000 miles, virtually every wear component throughout the vehicle has been renewed. It presents and drives like a freshly restored car rather than one reflecting its mileage.
Restoration Highlights
Body & Chassis
Complete bare shell restoration
Full welding repairs completed to as-new standard
Underside stripped, treated and professionally seam sealed
Full repaint inside and out
New Bilstein B12 suspension
New Eibach springs
Complete suspension overhaul
Powerflex Heritage bushes throughout
All underbody components refurbished
Exterior plastics repaired and refinished
⸻
Engine
Fully rebuilt engine
Cylinder head pressure tested, skimmed and rebuilt
New hydraulic lifters
Block rebored
New Mahle oversized pistons
Balanced rotating assembly
New oil pump
New sump
New cambelt and water pump
New auxiliary belts
New oil cooler
New distributor, ignition leads and Lucas Sports coil
Injectors professionally refurbished
New alternator
New starter motor
New idle control valve
Engine rebuilt using all new bearings, rings, seals, gaskets, studs, nuts and bolts
Three new engine mounts
⸻
Transmission
Fully reconditioned gearbox
All synchromesh renewed
New driveshafts
New LUK clutch kit
New release bearing
New clutch cable
Balanced flywheel
New linkage components
Short shift kit
⸻
Braking System
Upgraded G60 280mm front brake conversion
New front hubs and bearings
New front calipers
Rear Mk4 caliper upgrade
New discs and pads
Braided brake hoses
New hard brake lines
New handbrake cables
New four-port master cylinder
Refurbished servo
⸻
Interior
New headlining
Matching sun visors
Driver’s seat bolster professionally repaired
Interior stripped, cleaned and rebuilt
New clips and fittings throughout
Instrument cluster refurbished
New speaker covers
New speedometer cable
Dashboard completely dismantled and rebuilt
Extensive Dynamat sound deadening fitted throughout
⸻
Wheels & Tyres
Refurbished BBS RA alloy wheels
Four Michelin Pilot Sport 3 tyres
Stud and spacer conversion
⸻
Additional Restoration Work
Complete engine bay refurbishment
New cooling hoses
New radiator
New sensors throughout
Complete replacement wiring harness rewrapped in cloth tape
New Yuasa battery
Battery isolator switch
Power steering rack and pump refurbished
All nuts, bolts and fixings zinc plated
Aluminium components vapour blasted
Subframe, axle and suspension components powder coated
⸻
Documentation
The car is supplied with:
Extensive restoration documentation
DS Motorsport restoration record
MOT until September 2026
Supporting paperwork
⸻
Condition
Finding a Mk2 GTI restored to this level is becoming exceptionally difficult. The quality of workmanship is immediately apparent throughout the vehicle, from the underside to the engine bay and interior.
This is an investment-grade example suitable for collectors and enthusiasts alike, equally at home at concours events or enjoyed on the road.
The mileage is largely irrelevant given the extent of the restoration; virtually every significant mechanical and cosmetic component has been rebuilt or replaced.
If you are searching for one of the finest Mk2 GTIs currently available, this example deserves serious consideration.
Please Note:
The above Specification is as accurate as we can establish,
but it is ultimately the responsibility of the Purchaser to
check the details of the vehicle to their satisfaction before
buying. Hamilton Gray’s are Not Responsible ‘Post Sale’
Date of Registration 22.08.1991 / MOT Till 23.09.2026
We have the V5 logbook and will look after your cherished transfer with the DVLA if you own a cherished plate.
Any inspection is welcome and viewings are highly recommended at our indoor showroom. We are based in Loughborough, Leicestershire which is just 5 minutes drive from Junction 23 of the M1.
We accept all major debit or credit cards and finance is available, subject to status.
Legal Disclaimer: Hamilton Gray’s Ltd make every effort to ensure that information contained in their adverts is accurate and complete, however, errors and omissions may occur from time to time and we are unable to guarantee the accuracy of said information, and therefore cannot be held liable for any reliance which you may place upon it.
